Product ID:PR-WASH PRETREAT FORM 117 METALS ID728014
MSDS Date:10/14/1988
FSC:8030
NIIN:00-281-2726
Kit Part:Y
MSDS Number: BDSTM

PRATT AND LAMBERT INC

16116 E 13TH ST
WICHITA, KS 67201
US

Emergency Phone: 716-873-6000 DOT EMER 8002553924

Info Phone: 316-733-1361

Preparer: W.A. ELLISON

Cage: 61196

PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

OSHA PEL 0.1 MG/M3 (CRO3)

ACGIH TLV: 0.01MG/M3(CR)A1;9192

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PHOSPHORIC ACID

CAS: 664-38-2

OSHA PEL 1 MG/CU.M

ACGIH TLV: 1 MG/CU.M

VOC. ORGANIC CMPD 5.0 LB/GAL LESS WATER & NPRS* 600 G/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLONGED OVEREXPOSURE TO RELATIVELY
INSOLUBLE CHROMATES MAY CAUSE LUNG CANCER, DERMATITIS & EROSION OF
THE TEETH. MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENT MISUSE BY DELIBERATE CONCEN & INHAL OF CONTENTS MAY BE
HARMFUL OR FATAL.
Explanation of Carcinogenicity:ZINC CHROMATE HAS BEEN LISTED AS A
POTENTIAL CARCINOGEN BY THE INTERANATIONAL AGENCY FOR RESEARCH ON
CANCER
Effects of Overexposure:INGES: SEVERE BURNS OF CMUCOUS MEMBRANES OF
MOUTH ESOPHAGUS, STOMACH PAIN, NAUSEA, VOMIT. GASTROINTESTINAL
IRRI, ASPIRATION INTO LUNG, CHEM PNEUMONITIS, FATAL. INHAL: SEVERE
IRRI, COUGH, BURNING THROA T, CHOKING, PULMONARY EDEMA. EYE: SEVERE
IRRI & CORNEAL DAM. SKIN: ABSORB LRG AMTS, SEVERE BURNS UNLESS
WASHED OFF IMMED
Medical Cond Aggravated by Exposure:NONE LISTED. NOTES TO PHYSICIAN:
ANY TREATMENT THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE
DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.

First Aid:SWALLOW: DO NOT INDUCE VOMIT. GIVE 1 OR 2 GLASS OF WTR TO
DILUTE. NEVER BY MOUTHTO UNCONS PERSON. CALL POISON CONTROL CENTER,
HOSPITAL, PHYSICIAN IMMED. INHAL: REMOVE TO FRESH AIR IMMED. IF
BREATH STO PPED GIVE CPR/OXYGEN IF NEEDED. KEEP WARM & QUIET. GET
MED ATTN IMMED. EYE: FLUSH LRG AMTS OF WTR, LIFTING LIDS 15 MIN.
GET MED ATTN. SKIN: IMMED FLUSH LRG AMT WTR. REMOVE CONTAM CLOTHES.
PHYSICIAN

Flash Point:53 F/ 12 C
Extinguishing Media:NFPA CL B FIRE EXTING (CARBON DIOXIDE, ALL PURPOSE
DRY CHEM OR ALCOHOL FOAM) FOR FLAMM LIQ FIRES. POLYMER FOAM IS
PREFER
Fire Fighting Procedures:WEAR SELF CONTAIN BREATHING APPARATUS. WTR
INEFFECTIVE, BUT USED TO COOL CONTAINERS, PREVENT PRESSURE BUILD
UP/POSS AUTO IGNITE/EXPLOSION FROM HEAT. FOG NOZZLE
Unusual Fire/Explosion Hazard:EMERGENCY COND OVEREXPOSURE TO DECOMP MAY
CAUSE HEALTH HAZARD. SYMP MAY NOT BE IMMED APPARENT. OBTAIN MEDICAL
ATTENTION. WARNING! FLAMMABLE.

Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE EQUIP. VENT AREA
OF LEAK. STOP LEAK. CONFINE/COLLECT SPILL MATERIAL. DILUTE &/OR
NEUTRALIZE. KEEP SPECTATORS AWAY. ELIMINATE INGITE SOURCES. DIKE &
CONTAIN SPILL W/INERT MA TERIAL. TRANS LIQ TO COVERED METAL
CONTAINER.

Handling and Storage Precautions:DO NOT STORE ABOVE 95 DEG F. STORE LRG
AMTS IN COMPLIANCE WITH OSHA. USE ONLY NON-SPARKING TOOLS. PLACE
ABSORBENT DIKING MATERIAL IN COVER METAL CONT
Other Precautions:PREVENT CONTAMINATION OF SEWERS, STREAMS, AND
GROUNDWATER W/SPILLED MATERIAL OR USED ABSORBENT. DO NOT TAKE
INTERNALLY. CLOSED CONTAIENR AFTER EACH USE. EMPTY CONTAINERS MUST
NOT BE WASHED AND REUSED FOR ANY PURPOSE. CONTAIN SHOULD GROUNDED

Respiratory Protection:GEN EXPOSURE TO ORGNAIC CHEM MAY NOT REQUIRE USE
OF RESPIR PROTECT IF WELL VENT AREA. RESTRICTED VENT AREA A NIOSH
APPROVED CHEM CARTRIDGE RESPIR MAY BE REQUIRED. UNDER SPRAY, ETC
MECH PREFILTER REQUI RED. CONFINED-AIR SUPPLIED RESPIRATOR
Ventilation:GENERAL DILUTION & LOCAL EXHAUST VENT SUFFICIENT
VOL/PATTERNTO MAINTAIN CONCEN OF HAZARD SUB TO BELOW LOWEST LIMITS
Protective Gloves:IMPERMEABLE GLOVES FOR PROLONGED USE
Eye Protection:SAFETY SPECTACLES, CHEM SPLASH GOGGLES
Other Protective Equipment:EYE WASH FACILITY AND SAFETY SHOWER
Work Hygienic Practices:GOOD GENERAL HYGIENE PRACTICES
Supplemental Safety and Health
DO NOT WELD, BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO
EMPTY. DRUM IS NOT A PRESSURE VESSEL

HCC:F2
Boiling Pt:B.P. Text:180-500 F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:90

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:NORMALLY STABLE
Hazardous Decomposition Products:BURNING, INCLUD WHEN HEAT BY
WELD/CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE, CARBON DIOXIDE.
OXIDES OF CHROMIUM GENER
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND FLAME

Waste Disposal Methods:ACCORD W/FED, STATE & LOCAL LAWS. INCIN ONLY IN
EPA PERMITTED FACILITY. DO NOT INCIN CLOSED CONTAIN.OBSERVE
PRECAUTIONS OF FLAMM. CONTAM ABSORB MAY BEDISPOSED IN A HAZARDOUS
WASTE LANDFILL. DISPOSE ON LY W/FED, STATE & LOCAL REG. HAZARDOUS
WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.